After playing around with Kev’s mod for a while, I realised that it’s just not going to do any good for my XT, and it had to go! But since my XT was not standard anymore, and I had no intentions of going backwards, so I thought I’ll try to improve it instead!
I can’t say that I was very happy paying that crazy money for Power Commander 5, but to be honest – once it was tuned by specialists to my XT660Z, it felt like a different bike! Huge difference!
Power wise not so much of the difference, but how it felt after was like day and night – so much smoother, all crazy popping and banging disappeared, throttle felt a lot more precise, all dead spots gone along with low rev struggles and hesitation!
What else was used on my XT
Just to be clear, this is what i had on my bike:
- Foam filter, no snorkel or any of the rings (reducers)
- O2 optimiser (piggy back style, that sits between the O2 sensor and ECU)
- AIS blocked off.
- Homemade exhaust. (You can read more about it here)
- Power Commander 5
Verdict!
Bonus point for PCV – chance to have 2 different maps switchable on the go with a switch! However it has a big minus point – most tuners can chip/tune xt660z ECU! It will cost a bit, but not as much as PCV + Tuning!
Shame I didn’t know that when I bought a PCV!
Explore More!
- Story of my lovely Bombproof Yamaha XT660Z tenere!
- Yamaha XT660Z Bearing and Seal Sizes – cheat sheet!
- How to make motorcycles Cable Clutch lighter! (Part 1/3)
- Cheap ways to make your motorcycles clutch lighter! (Part 2/3)
All Yamaha XT660Z faults and hiccups that left me scratching my head.
- How to fix rattling headlight reflector
- How the regulator rectifier overcharged my Tenere’s battery.
- Funny oil leak, or how i lost 1 liter of oil in 500 miles.
- Funny story: how my XT660Z fuel reserve light tricked me, leaving me stranded!
- How the starter relay got fried twice on my xt660z!
- How I fixed a squeaky / rattly dash on my xt660z!
All Yamaha XT660Z Mods!
- Hole in the air filter box (for rear shock removal).
- Heed crash bars.
- Barkbusters.
- Protaper adventure Evo Handlebars.
- Rally style clamps and handlebar risers.
- Ultimate addons case and Touratech gps bracket.
- Folding mirrors.
- Clamp type of bracket for dash.
- Wind Buffeting modification.
- Toolbox.
- Storage box for First Aid Kit.
- Folding screen extension – Modified.
- Paintwork.
- Seat Hump Removed – Flat Seat Mod
- Dynojet Power Commander V and power mods.
- Foam Air filter.
- Ohlins 6nm springs.
- Hyperpro progressive spring.
- Swingarm bearing modification.
- Wiring loom – switch controls.
- Fiberglass under seat storage.
- Shortened rear brake pedal with anchor and welded folding tip.
- Extended Clutch actuator arm.
- Shortened brake and clutch levers.
- Pivot pegs.
- Fuel tank air bleed modification.
- Shortened Side Stand.
- Lowered Rear end.
- Suspension Grease Niples.
- Lucas Regulator Rectifier.
Explore More!
A list of posts about Bike Maintenance and General Modifications that might be Interesting to know!
General Modifications:
- Throttle Tamer Mods (4 ways to tame your horse!)
- Projector headlight conversion from right side road traffic to left and vice versa.
- How to make your own Exhaust or how to modify an existing one.
- Power Commander (PCV) and Thoughts on it.
- Brake Snake / Pedal Anchor – why and how!
- Lighter Clutch Mods:
- How to make motorcycles Cable Clutch lighter! (Part 1/3)
- Cheap ways to make your motorcycles clutch lighter! (Part 2/3)
- How to make a Hydraulic clutch lighter on your motorcycle! (Part 3/3)
- How to make Custom Clutch or Throttle Cables – Easier than you thought!
- How to make clutch lever lighter (Yamaha XT660Z Tenere Specific)
- Rear Suspension and Drive-Train:
- How to extend the life of Cush-Drive rubbers.
- The dangers of motorcycle lowering links, Important things to know!
- How to swap rear shock spring with no special tools!
- The Best Motorcycle chain lube!
- How to set motorcycle chain slack when suspension is not standard?
- How To Remove Stubborn And Hard To Reach Chain Adjuster Bolt
- The List of Most Useless Adventure Motorcycle Mods And Bling!
- Dangers of the lowering kits (things to know before Lowering your Bike!
Bike Maintenance:
- How to pass MOT the first time – every time!
- How to Maintain your motorcycle Locks (works with all locks!)
- Best Suspension Bearing Grease!
- What grease to use on your motorcycle?
- How to shorten Life of your wheel bearings! (Or what not to do to them!)
- Why should you grease your bolts! (And not only Bearings!)
- What is the best Chain Lube for your motorcycle?
- How to buy used Motorcycle – Free Guide.